Rugged Ethernet & Timing Solutions
The CM-4018F10-MIL is a fully rugged managed gigabit Ethernet switch specially designed to operate reliably in harsh climatically and noisy electrical demanding environments (e.g. high altitude h that addresses complexity, enables modularity and provides growth, while delivering optimal performance for Space, Weight, Power, and Cost (SWaP-C) constrained military applications onboard military vehicles. The unit complies to the military environmental, EMC and power input requirements. This fully managed, Layer 2/3 gigabit switch provides a powerful set of networking features, including support for IPv4 multicast traffic filtering according to static filters or IGMP snooping, Virtual Local Area Networks (VLANs), port control (speed / mode / statistics, flow control), Quality of Service (QoS) traffic prioritization, Link Aggregation (802.3ad), SNMP v1/v2/v3 management, secure authentication (802.1X, ACLs, Web/CLI), port mirroring and network redundancy
based on RSTP/MSTP.
CM-4018F0-MIL | EMBEDDED OEM ETHERNET SWITCH
| FORM FACTOR | I – 93x165x65mm, J – No chassis (OEM) |
|---|
| Ethernet ports | |
| 10/100/1000BASE-T | 4 |
| Tap Properties | |
| Switch fabric properties | Store-and-forward and full wire speed on all ports with no packet queuing on tap ports |
| Management | HTTP/HTTPS |
| Connectors | |
| Ethernet copper connectors | FAS-T |
| Power connector | 10 pin bajonet |
| Connector spacing | According to MIL-STD-1472F |
| Data Zeroization Support | |
| Data Zeroization | To erase Non-Volatile Flash Memory and Restore Board to Factory Default Config- uration. Available via HTTP |
| Power | |
| Power Consumption (Typ.) | 8W |
| Overload Current Protection | Yes |
| Reverse Polarity Protection | Yes |
| Power input | 28VDC (22-32VDC) |
| Physical Characteristics | |
| Enclosure | Aluminum case |
| Dimension (W * D * H) | 149mm (W) x 95mm (D) x 45mm (H) / 5.86in (W) x 3.74in (D) x 1.78in (H) |
| Weight | 930g / 2.05lbs. |
| Surface finish | Powder paint on top of SurTec 650 |
| EMC/Enviromental | |
| Conducted Emission | MIL-STD-461F: CE101-4, Army and Navy ASW aircraft; MIL-STD-461F: CE102, 10KHz – 10MHz, power leads; RTCA DO-160G: chapter 17.4, Voltage spikes, 600V, category A; chapter 21.4, 0.15 – 152 MHz, category M |
| Conducted Susceptibility | MIL-STD-461F/G: CS101, Power Leads; CS114, Bulk Cable Injection, 10 KHz – 200 MHz; CS115, Bulk Cable Injection, 10 KHz – 200 MHz; CS116, Damped Sinusoidal Transients, Cables and Power Leads, 10 KHz – 100 MHz; CS118, Personnel Borne Electrostatic Discharge (ESD); RTCA DO-160G: chapter 15.3, Magnetic Effects, cat- egory C; chapter 20.4, 0.15 – 7.5mA, 10KHz – 400MHz, category T; chapter 25.5, ESD: +/- 15KV, category A |
| Radiated Emission | MIL-STD-461F: RE101, Magnetic Field, 30Hz – 100KHz, Army; RE102, Electric Field, All aircraft types, internal conditions; RTCA DO-160G: chapter 21.5, 100 – 6 000 MHz, category: M |
| Radiated Susceptibility | MIL-STD-461F: RS103, 2MHz-40MHz, 200V/m; RTCA DO-160G: chapter 20.5, 5 V/m, category: T |
| Operational Temperature | MIL-STD-810G: 501.5, 502.5 and 503.5; RTCA DO-160G: chapter 4.5.2 and 4.5.4, [-40..+71]C◦ |
| Storage Temperature | MIL-STD-810G: 502.5; RTCA DO-160G: chapter 4.5.1 and 4.5.3, [-40..+85]C◦ |
| Altitude | MIL-STD-810G: 500.5, 85.000ft; RTCA DO-160G: chapter 4.6.1: 50.000ft; chapter 4.6.2: decompression |
| Operational vibration | MIL-STD-810G: 514.6, procedure I (up to 10g); RTCA DO-160G: chapter 8, S (fixed wing), Zone 2 (equipment rack), aircraft type 3, curve M |
| Shock | MIL-STD-810G: 516.6, procedure V (40g, 11ms); 516.4, procedure 1 (30g, 11ms); RTCA DO-160G: chapter 7.5.2 (6g, 11ms); chapter 7.5.3 (20g, 11ms) |
| Acceleration loads | MIL-STD-810G: Method 513.6 (operational: 24g, ultimate load: 35.9g) RTCA DO- 160G: chapter 7.3.3 (18g – sustained) |
FLIGHT-RATED ETHERNET SWITCHES
CM-6200 AER SERIES | 128pins – MANAGED AIRCRAFT ETHERNET SWITCH
GROUND & SHIPBOARD ETHERNET SWITCHES
GROUND & SHIPBOARD ETHERNET SWITCHES
CM-7000-MIL SERIES | MANAGED MILITARY GIGABIT ETHERNET SWITCH
GROUND & SHIPBOARD ETHERNET SWITCHES
CM-6200 MIL SERIES | 128pins D38999 – MILITARY ETHERNET SWITCH
GROUND & SHIPBOARD ETHERNET SWITCHES
CM-6200 MIL SERIES | 22pins D38999 – MILITARY ETHERNET SWITCH
FLIGHT-RATED ETHERNET SWITCHES
FLIGHT-RATED ETHERNET SWITCHES
