Rugged Ethernet & Timing Solutions
The CM-4006F0-AER is a fully rugged managed gigabit Ethernet switch specially designed to operate reliably in harsh climatically and noisy electrical demanding environments (e.g. high altitude, extreme shock, and vibration, wide temperatures, humidity, dust and water exposure, noisy EMI, dirty power) of military applications. The platform is an advanced and highly engineered switch that addresses complexity, enables modularity, and provides growth while delivering optimal performance for Space, Weight, Power and Cost (SWaP-C) constrained aircraft applications
onboard helicopters and fixed-wing aircraft. The unit complies with the military environmental, EMC, and power input requirements.
This fully managed, Layer 2/3 gigabit switch provides a powerful set of networking features, including support for IPv4 multicast traffic filtering according to static filters or IGMP snooping, Virtual Local Area Networks (VLANs), port control (speed / mode / statistics, flow control), Quality of Service (QoS) traffic prioritization, Link Aggregation (802.3ad), SNMP v1/v2/v3 management, secure authentication (802.1X, ACLs, Web/CLI), port mirroring and network redundancy based on RSTP/MSTP.
PTP: PTP TC
NTP: Standard NTP server
TAP: No Tap
CONNECTOR: 1x 55 pins D38999 for 6x 1G-T
POWER: 28VDC
POWER CONNECTOR TYPE: 5 pin D38999
POWER HOLD UP: 250ms
| Ethernet ports | |
| 10/100/1000BASE-T | 6 |
| Switch protocols | |
| Standards | IEEE 802.3x for Flow control IEEE 802.3ad for LACP (Link Aggregation Control Protocol) IEEE 802.1D for STP (Spanning Tree Protocol) IEEE 802.1p for COS (Class of Service) IEEE 802.1Q for VLAN Tagging IEEE 802.1w for RSTP (Rapid Spanning Tree Protocol) IEEE 802.1s for MSTP (Multiple Spanning Tree Protocol) IEEE 802.1X for Authentication IEEE 802.1AB for LLDP (Link Layer Discovery Protocol) IEEE 1588 (PTPv1 and PTPv2) |
| MAC table | 8192 MAC addresses |
| Priority queues | 8 |
| Switch fabric properties | Store-and-forward and full wire speed on all ports |
| Security Features | Enable/disable ports, MAC based port security Port based network access control (802.1x) VLAN (802.1Q ) to segregate and secure network traffic. Radius centralized password management SNMPv3 encrypted authentication and access security |
| Management | HTTP/HTTPS, telnet/SSHv2, CLI and SNMP v1/v2/v3 |
| Built-in test | Built-in test procedure performed at boot time. Continuous BIT procedure when device is powered |
| Other protocols | IGMP snooping (up to 1024 multicast filters) Static multicast filter setting Port rate limiting DHCP TOS/Diffserv supported Quality of Service (802.1Q) for real-time traffic VLAN (802.1Q) with VLAN tagging and MVR Port configuration, status, statistics, monitoring, security |
| Other I/O | |
| RS232 | 1 port, settings: 115200, N, 8, 1 (CLI console) |
| PPS | Pulse-Per-Second (PPS) output |
| Connectors | |
| Ethernet copper connectors | D38999 |
| Power connector | 5 pin D38999 |
| Connector spacing | According to MIL-STD-1472F |
| Data Zeroization Support | |
| Data Zeroization | To erase Non-Volatile Flash Memory and Restore Board to Factory Default Config- uration. Available via HTTP and CLI |
| Power | |
| Power Consumption (Typ.) | 9W |
| Overload Current Protection | Yes |
| Reverse Polarity Protection | Yes |
| Power input | 28VDC (22-32VDC) |
| Hold-up | 250ms |
| Physical Characteristics | |
| Enclosure | Aluminum case |
| Dimension (W * D * H) | 154.15mm (W) x 81mm (D) x 53.1mm (H) / 6.07in (W) x 3.19in (D) x 2.09in (H) |
| Weight | 850g / 1.87lbs. |
| Surface finish | Powder paint on top of SurTec 650 |
| EMC/Enviromental | |
| Conducted Emission | MIL-STD-461F: CE101-4, Army and Navy ASW aircraft; MIL-STD-461F: CE102, 10KHz – 10MHz, power leads; RTCA DO-160G: chapter 17.4, Voltage spikes, 600V, category A; chapter 21.4, 0.15 – 152 MHz, category M |
| Conducted Susceptibility | MIL-STD-461F/G: CS101, Power Leads; CS114, Bulk Cable Injection, 10 KHz – 200 MHz; CS115, Bulk Cable Injection, 10 KHz – 200 MHz; CS116, Damped Sinusoidal Transients, Cables and Power Leads, 10 KHz – 100 MHz; CS118, Personnel Borne Electrostatic Discharge (ESD); RTCA DO-160G: chapter 15.3, Magnetic Effects, cat- egory C; chapter 20.4, 0.15 – 7.5mA, 10KHz – 400MHz, category T; chapter 25.5, ESD: +/- 15KV, category A |
| Radiated Emission | MIL-STD-461F: RE101, Magnetic Field, 30Hz – 100KHz, Army; RE102, Electric Field, All aircraft types, internal conditions; RTCA DO-160G: chapter 21.5, 100 – 6 000 MHz, category: M |
| Radiated Susceptibility | MIL-STD-461F: RS103, 2MHz-40MHz, 200V/m; RTCA DO-160G: chapter 20.5, 5 V/m, category: T |
| Operational Temperature | MIL-STD-810G: 501.5, 502.5 and 503.5; RTCA DO-160G: chapter 4.5.2 and 4.5.4, [-40..+71]C◦ |
| Storage Temperature | MIL-STD-810G: 502.5; RTCA DO-160G: chapter 4.5.1 and 4.5.3, [-40..+85]C◦ |
| Altitude | MIL-STD-810G: 500.5, 85.000ft; RTCA DO-160G: chapter 4.6.1: 50.000ft; chapter 4.6.2: decompression |
| Operational vibration | MIL-STD-810G: 514.6, procedure I (up to 10g); RTCA DO-160G: chapter 8, S (fixed wing), Zone 2 (equipment rack), aircraft type 3, curve M |
| Shock | MIL-STD-810G: 516.6, procedure V (40g, 11ms); 516.4, procedure 1 (30g, 11ms); RTCA DO-160G: chapter 7.5.2 (6g, 11ms); chapter 7.5.3 (20g, 11ms) |
| Acceleration loads | MIL-STD-810G: Method 513.6 (operational: 24g, ultimate load: 35.9g) RTCA DO- 160G: chapter 7.3.3 (18g – sustained); |
GROUND & SHIPBOARD ETHERNET SWITCHES
CR-6200 MIL SERIES | 128pins – MILITARY ETHERNET SWITCH & ROUTER
FLIGHT-RATED ETHERNET SWITCHES
GROUND & SHIPBOARD ETHERNET SWITCHES
CM-7000-MIL SERIES | MANAGED MILITARY GIGABIT ETHERNET SWITCH
GROUND & SHIPBOARD ETHERNET SWITCHES
CM-6200 MIL SERIES | 22pins D38999 – MILITARY ETHERNET SWITCH
GROUND & SHIPBOARD ETHERNET SWITCHES
CM-6200 GMC MIL SERIES | 22pins D38999 – MILITARY ETHERNET SWITCH
FLIGHT-RATED ETHERNET SWITCHES
GROUND & SHIPBOARD ETHERNET SWITCHES
FLIGHT-RATED ETHERNET SWITCHES
CM-6200 AER SERIES | 128pins – MANAGED AIRCRAFT ETHERNET SWITCH
